废食用植物油生物基增塑剂的研究进展

›› 2023, Vol. 37 ›› Issue (4): 104-111.

废食用植物油生物基增塑剂的研究进展

王妮,赵晓颖,翁云宣

北京工商大学

收稿日期:2022-12-15 修回日期:2022-12-24 出版日期:2023-04-26 发布日期:2023-04-26
基金资助:
国家自然科学基金青年科学基金;高层次人才队伍建设

Research progress in waste cooking vegetable oil bio-based plasticizers

Received:2022-12-15 Revised:2022-12-24 Online:2023-04-26 Published:2023-04-26

摘要/Abstract

摘要： 对废食用植物油生物基增塑剂及其环氧化工艺进行了综述，总结了废食用植物油环氧化工艺的均相酸催化法、酸性离子交换树脂催化法和脂肪酶催化法3种常见方法，并分别对其催化原理和特点进行了阐述，同时对废食用植物油生物基增塑剂的应用进行了梳理和展望。

关键词: 废食用植物油, 生物基增塑剂, 环氧化工艺

Abstract: This paper summarized the epoxidation process of waste cooking vegetable oil bio-based plasticizer and introduced three common epoxidation methods， including homogeneous acid catalysis， acidic ion exchange resin catalysis， and enzymes catalysis. The catalytic principle and characteristics were expounded separately. Finally， the application of waste cooking vegetable oil bio-based plasticizers was discussed and prospected.

Key words: waste cooking vegetable oil, bio-based plasticizer, epoxidation process

王妮赵晓颖翁云宣. 废食用植物油生物基增塑剂的研究进展[J]. , 2023, 37(4): 104-111.

参考文献

[1] Azzena U, Montenero A, Carraro M, et al. Recovery, Purification, Analysis and Chemical Modification of a Waste Cooking Oil [J]. Waste and Biomass Valorization, 2022,
[2] 温金梅. GB 2716—2018《食品安全国家标准植物油》标准解读 [J]. 中国质量与标准导报, 2018, 11): 19-21.
[3] Orjuela A, Clark J. Green chemicals from used cooking oils: Trends, challenges, and opportunities [J]. Curr Opin Green Sustain Chem, 2020, 26(100369.
[4] Hosseinzadeh-Bandbafha H, Li C, Chen X, et al. Managing the hazardous waste cooking oil by conversion into bioenergy through the application of waste-derived green catalysts: A review [J]. J Hazard Mater, 2022, 424(Pt C): 127636.
[5] Cong P, Chen B, Zhao H. Coupling effects of wasted cooking oil and antioxidant on aging of asphalt binders [J]. International Journal of Pavement Research and Technology, 2019, 13(1): 64-74.
[6] 王瑞元. 2021年我国粮油产销和进出口情况 [J]. 中国油脂, 2022, 47(06): 1-7.
[7] 何鑫, 吴桂英, 闫云君. 植物油基平台化合物及高分子材料研究进展 [J]. 生物工程学报, 2017, 33(05): 701-719.
[8] 熊万明, 余冬冬, 孔娟花, et al. 餐饮废弃油的理化性质与成分分析 [J]. 化学研究与应用, 2017, 29(02): 178-182.
[9] Paul AK, Borugadda VB, Bhalerao MS, et al. In situ epoxidation of waste soybean cooking oil for synthesis of biolubricant basestock: A process parameter optimization and comparison with RSM, ANN, and GA [J]. The Canadian Journal of Chemical Engineering, 2018, 96(7): 1451-1461.
[10] Zhang Z, Jiang P, Liu D, et al. Research progress of novel bio-based plasticizers and their applications in poly(vinyl chloride) [J]. Journal of Materials Science, 2021, 56(17): 10155-10182.
[11] Alsofiany AA, Faiz Mukhtar Gunam Resul M. Epoxidation of Waste Cooking Palm Oil with Peracetic Acid Catalyzed by Sulfuric Acid [M]. 2021 International Congress of Advanced Technology and Engineering (ICOTEN). 2021: 1-5.
[12] Moser BR, Cermak SC, Doll KM, et al. A review of fatty epoxide ring opening reactions: Chemistry, recent advances, and applications [J]. Journal of the American Oil Chemists' Society, 2022, 99(10): 801-842.
[13] Ramírez LM, Cadavid JG, Orjuela A, et al. Epoxidation of used cooking oils: Kinetic modeling and reaction optimization [J]. Chemical Engineering and Processing - Process Intensification, 2022, 176(
[14] Zheng T, Wu Z, Xie Q, et al. Structural modification of waste cooking oil methyl esters as cleaner plasticizer to substitute toxic dioctyl phthalate [J]. Journal of Cleaner Production, 2018, 186(1021-1030.
[15] Mannu A, Ferro M, Colombo Dugoni G, et al. Response Surface Analysis of density and flash point in recycled Waste Cooking Oils [J]. Chemical Data Collections, 2020, 25(
[16] L. Abubakar A, A. Sokoto M, J. Owuna F, et al. Assessment of Quality Parameters of Ecofriendly Biolubricant from Waste Cooking Palm Oil [J]. Asian Journal of Applied Chemistry Research, 2018, 1-11.
[17] Ho YH, Parthiban A, Thian MC, et al. Acrylated Biopolymers Derived via Epoxidation and Subsequent Acrylation of Vegetable Oils [J]. International Journal of Polymer Science, 2022, 2022(1-12.
[18] López-Fernández J, Moya D, Dolors Benaiges M, et al. Near Infrared Spectroscopy: A useful technique for inline monitoring of the enzyme catalyzed biosynthesis of third-generation biodiesel from waste cooking oil [J]. Fuel, 2022, 319(
[19] Daniels PH. A brief overview of theories of PVC plasticization and methods used to evaluate PVC-plasticizer interaction [J]. Journal of Vinyl and Additive Technology, 2009, 15(4): 219-223.
[20] 陈光剑, 陈永波, 杨朝建, et al. 复合增塑剂改性PBAT/淀粉薄膜的性能 [J]. 工程塑料应用, 2022, 50(02): 150-154.
[21] Chen F, Peng D, Ogata Y, et al. Confinement Effect on the Effective Viscosity of Plasticized Polymer Films [J]. Macromolecules, 2015, 48(20): 7719-7726.
[22] Omrani I, Ahmadi A, Farhadian A, et al. Synthesis of a bio-based plasticizer from oleic acid and its evaluation in PVC formulations [J]. Polymer Testing, 2016, 56(237-244.
[23] Najafi V, Abdollahi H. Internally plasticized PVC by four different green plasticizer compounds [J]. European Polymer Journal, 2020, 128(
[24] Jia P, Xia H, Tang K, et al. Plasticizers Derived from Biomass Resources: A Short Review [J]. Polymers (Basel), 2018, 10(12):
[25] Lavorgna M, Piscitelli F, Mangiacapra P, et al. Study of the combined effect of both clay and glycerol plasticizer on the properties of chitosan films [J]. Carbohydrate Polymers, 2010, 82(2): 291-298.
[26] Rahman M, Brazel C. The plasticizer market: an assessment of traditional plasticizers and research trends to meet new challenges [J]. Progress in Polymer Science, 2004, 29(12): 1223-1248.
[27] Isotton FS, Bernardo GL, Baldasso C, et al. The plasticizer effect on preparation and properties of etherified corn starchs films [J]. Industrial Crops and Products, 2015, 76(717-724.
[28] Goodwin JM, Rana H, Ndungu J, et al. Hydrogen peroxide inhibition of bicupin oxalate oxidase [J]. PLoS One, 2017, 12(5): e0177164.
[29] Pyeon HB, Park JE, Suh DH. Non-phthalate plasticizer from camphor for flexible PVC with a wide range of available temperature [J]. Polymer Testing, 2017, 63(375-381.
[30] de Fátima Po?as M, Hogg T. Exposure assessment of chemicals from packaging materials in foods: a review [J]. Trends in Food Science & Technology, 2007, 18(4): 219-230.
[31] Lee J, Choi K, Park J, et al. Bisphenol A distribution in serum, urine, placenta, breast milk, and umbilical cord serum in a birth panel of mother-neonate pairs [J]. Sci Total Environ, 2018, 626(1494-1501.
[32] Benjamin S, Masai E, Kamimura N, et al. Phthalates impact human health: Epidemiological evidences and plausible mechanism of action [J]. J Hazard Mater, 2017, 340(360-383.
[33] Lin LY, Tsai MS, Chen MH, et al. Childhood exposure to phthalates and pulmonary function [J]. Sci Total Environ, 2018, 615(1282-1289.
[34] Chen J, Zhou J, Liu W, et al. Enzymatic epoxidation of soybean oil in the presence of perbutyric acid [J]. Chemical Papers, 2017, 71(11): 2139-2144.
[35] Yang D, Peng X, Zhong L, et al. "Green" films from renewable resources: properties of epoxidized soybean oil plasticized ethyl cellulose films [J]. Carbohydr Polym, 2014, 103(198-206.
[36] Fenollar O, Garcia-Sanoguera D, Sanchez-Nacher L, et al. Effect of the epoxidized linseed oil concentration as natural plasticizer in vinyl plastisols [J]. Journal of Materials Science, 2010, 45(16): 4406-4413.
[37] Hosney H, Nadiem B, Ashour I, et al. Epoxidized vegetable oil and bio-based materials as PVC plasticizer [J]. Journal of Applied Polymer Science, 2018, 135(20):
[38] Li X, Nie X, Chen J, et al. Preparation of epoxidized cardanol butyl ether as a novel renewable plasticizer and its application for poly(vinyl chloride) [J]. Polymer International, 2017, 66(3): 443-449.
[39] Kousaalya AB, Beyene SD, Gopal V, et al. Green epoxy synthesized from Perilla frutescens: A study on epoxidation and oxirane cleavage kinetics of high-linolenic oil [J]. Industrial Crops and Products, 2018, 123(25-34.
[40] Wai PT, Jiang P, Shen Y, et al. Catalytic developments in the epoxidation of vegetable oils and the analysis methods of epoxidized products [J]. RSC Adv, 2019, 9(65): 38119-38136.
[41] Shi H, Zhang Z, Wang Y. Mechanism on epoxidation of alkenes by peracids: A protonation-promoted pathway and its quantum chemical elucidation [J]. Journal of Molecular Catalysis A: Chemical, 2005, 238(1-2): 13-25.
[42] Goud VV, Patwardhan AV, Pradhan NC. Studies on the epoxidation of mahua oil (Madhumica indica) by hydrogen peroxide [J]. Bioresource Technology, 2006, 97(12): 1365-1371.
[43] Vianello C, Piccolo D, Lorenzetti A, et al. Study of Soybean Oil Epoxidation: Effects of Sulfuric Acid and the Mixing Program [J]. Industrial & Engineering Chemistry Research, 2018, 57(34): 11517-11525.
[44] Kurańska M, Bene? H, Prociak A, et al. Investigation of epoxidation of used cooking oils with homogeneous and heterogeneous catalysts [J]. Journal of Cleaner Production, 2019, 236(
[45] Sinaga MS, Tampubolon HR, Ermawati, et al. Production of epoxy compounds from unsaturated fatty acids derived from crystallization of used cooking oil [J]. International Conference on Agribusiness, Food and Agro-Technology, 2018, 205(
[46] Polese R, Pintus E, Nuvoli L, et al. Aquivion perfluorosulfonic superacid as an effective catalyst for selective epoxidation of vegetable oils [J]. R Soc Open Sci, 2022, 9(4): 211554.
[47] Freites Aguilera A, H?m?l?inen R, Er?nen K, et al. Prilezhaev epoxidation of oleic acid in the presence and absence of ultrasound irradiation [J]. Journal of Chemical Technology & Biotechnology, 2021, 96(7): 1874-1881.
[48] Chen J, de Liedekerke Beaufort M, Gyurik L, et al. Highly efficient epoxidation of vegetable oils catalyzed by a manganese complex with hydrogen peroxide and acetic acid [J]. Green Chemistry, 2019, 21(9): 2436-2447.
[49] Narowska BE, Ku?a?yński M, ?ukaszewicz M. Application of Activated Carbon to Obtain Biodiesel from Vegetable Oils [J]. Catalysts, 2020, 10(9):
[50] 王涵颖. 环氧-开环法制备植物油基多元醇及其应用 [D]; 江南大学, 2021.
[51] Kurańska M, Niemiec M. Cleaner Production of Epoxidized Cooking Oil Using A Heterogeneous Catalyst [J]. Catalysts, 2020, 10(11): 1261.
[52] Boz N, Degirmenbasi N, Kalyon DM. Esterification and transesterification of waste cooking oil over Amberlyst 15 and modified Amberlyst 15 catalysts [J]. Applied Catalysis B: Environmental, 2015, 165(723-730.
[53] Borugadda VB, Goud VV. Improved thermo-oxidative stability of structurally modified waste cooking oil methyl esters for bio-lubricant application [J]. Journal of Cleaner Production, 2016, 112(4515-4524.
[54] Stergiou PY, Foukis A, Filippou M, et al. Advances in lipase-catalyzed esterification reactions [J]. Biotechnol Adv, 2013, 31(8): 1846-1859.
[55] Zhang X, Wan X, Cao H, et al. Chemo-enzymatic epoxidation of Sapindus mukurossi fatty acids catalyzed with Candida sp. 99–125 lipase in a solvent-free system [J]. Industrial Crops and Products, 2017, 98(10-18.
[56] Ortiz C, Ferreira ML, Barbosa O, et al. Novozym 435: the “perfect” lipase immobilized biocatalyst? [J]. Catalysis Science & Technology, 2019, 9(10): 2380-2420.
[57] Zhang W, Ji H, Song Y, et al. Green preparation of branched biolubricant by chemically modifying waste cooking oil with lipase and ionic liquid [J]. Journal of Cleaner Production, 2020, 274(
[58] Seniha Güner F, Ya?c? Y, Tuncer Erciyes A. Polymers from triglyceride oils [J]. Progress in Polymer Science, 2006, 31(7): 633-670.
[59] Bueno-Ferrer C, Garrigós MC, Jiménez A. Characterization and thermal stability of poly(vinyl chloride) plasticized with epoxidized soybean oil for food packaging [J]. Polymer Degradation and Stability, 2010, 95(11): 2207-2212.
[60] Qiu F, Tang R, Zuo X, et al. A genome-wide association study identifies six novel risk loci for primary biliary cholangitis [J]. Nat Commun, 2017, 8(14828.
[61] Kamrin MA. Phthalate risks, phthalate regulation, and public health: a review [J]. J Toxicol Environ Health B Crit Rev, 2009, 12(2): 157-174.
[62] Suzuki AH, Botelho BG, Oliveira LS, et al. Sustainable synthesis of epoxidized waste cooking oil and its application as a plasticizer for polyvinyl chloride films [J]. European Polymer Journal, 2018, 99(142-149.
[63] Cai D-L, Yue X, Hao B, et al. A sustainable poly(vinyl chloride) plasticizer derivated from waste cooking oil [J]. Journal of Cleaner Production, 2020, 274(
[64] Jia P, Zhang M, Hu L, et al. A Strategy for Nonmigrating Plasticized PVC Modified with Mannich base of Waste Cooking Oil Methyl Ester [J]. Sci Rep, 2018, 8(1): 1589.