季铵醚化-辛烯基琥珀酸酯化淀粉与PVA共混膜力学性能研究

doi:10.19491/j.issn.1001-9278.2018.11.011

中国塑料 ›› 2018, Vol. 32 ›› Issue (11): 66-70.DOI: 10.19491/j.issn.1001-9278.2018.11.011

季铵醚化-辛烯基琥珀酸酯化淀粉与PVA共混膜力学性能研究

徐珍珍^1,2,祝志峰¹，张朝辉²，何神涛²

1. 江南大学生态纺织教育部重点实验室 2. 安徽工程大学纺织面料安徽省重点实验室

收稿日期:2018-06-26 修回日期:2018-07-30 出版日期:2018-11-26 发布日期:2018-12-24
基金资助:
安徽省高校自然科学研究重大项目（KJ2018ZD012）；安徽省科技厅对外国际合作项目（1704e1002213）

Study on Mechanical Properties of Quaternized and Octenylsuccinylated Starch/PVA Blend Films

Received:2018-06-26 Revised:2018-07-30 Online:2018-11-26 Published:2018-12-24
Contact: zhen-zhen XU E-mail:782292819@qq.com

摘要/Abstract

摘要： 为克服淀粉膜脆且硬的缺陷，制备季铵醚化-辛烯基琥珀酸酯化淀粉（QAS），并将它与聚乙烯醇（PVA）进行混合来制备共混膜；用X射线衍射仪进行共混膜结晶度测定，用扫描电子显微镜观察共混膜的表面形貌，研究QAS/PVA共混比和PVA结构对共混膜力学性能的影响。结果表明，QAS/PVA共混膜的结晶度比QAS膜的结晶度有所降低；随着QAS含量的增加，共混膜的断裂伸长率逐渐减小，断裂强度先减小后增大，当QAS/PVA共混比为50/50（质量比，下同）时，断裂强度达到最小值；随着PVA聚合度和醇解度的增加，共混膜的断裂强度和断裂伸长率也随之增大。

Abstract: To overcome the rigid and brittle defects in starch films,quaternized and octenylsuccinylated starch (QAS) was prepared and then mixed with poly(vinyl alcohol) (PVA) to prepare blend films. The crystallinity of the blend films was measured by X-ray diffractometer, and their surface morphology was observed with scanning electron microscope. The effects of QAS/PVA weight ratio and PVA structure on the mechanical properties of the blend films wereinvestigated. The results indicated that the degree of crystallinity of blend films was lower than that of pure QAS film. The elongation at break of blend films decreased gradually with an increase of QAS content,but their breaking strength decreased with the QAS content at first and then tended to increase. The blend films exhibitedminimum breaking strength at the QAS/PVA weight ratio of 50/50. Moreover, the breaking strength and elongation at break both increased with the increase of polymerization and alcoholysis degrees of PVA.

徐珍珍祝志峰张朝辉何神涛. 季铵醚化-辛烯基琥珀酸酯化淀粉与PVA共混膜力学性能研究[J]. 中国塑料, 2018, 32(11): 66-70.

参考文献

[1] 廖丽莎,刘宏生,刘兴训,等. 淀粉的微观结构与加工过程中相变研究进展[J]. 高分子学报, 2014,14 (6):761-773.
LIAO L S, LIU H S, LIU X X, et al. Development of microstructures and phase transitions of starch[J]. Acta Polymeric Sinica, 2014, 14(6):761-773.
[2] 章林艳,祝志峰. 接枝率对CS-g-PAA粘合与薄膜性能的影响[J]. 应用化工, 2015, 44(6):1068-1071.
ZHANG L Y, ZHU Z F. Effects of grafting ratio on the adhesion-to-fibers and film properties of CS-g-PAA[J]. Applied Chemical Industry, 2015, 44(6):1068-1071.
[3] 夏鹏, 徐亚雷, 侯连龙. 全生物降解淀粉塑料的研究进展[J]. 中国塑料, 2012, 26(12): 8-13.
Xia P, Xu Y L, Hou L L. Research progress in total biodegradable starch plastics [J]. China Plastics, 2012, 26(12): 8-13.
[4] ZHU Z F, ZHANG L Q, LI M L, et al. Effects of starch alkenylsuccinylation on the grafting efficiency, paste viscosity, and film properties of alkenylsuccinylated starch-g-poly(acrylic acid)[J]. Starch, 2012, 64(9):704-712.
[5] 雷岩,祝志峰. 取代基的烷基链长对季铵阳离子淀粉浆膜性能的影响[J]. 东华大学学报:自然科学版, 2015, 41(5): 625-630.
LEI Y, ZHU Z F. Effect of chain length of the alkyl in substituent on the properties of quaternary ammonium starch film[J]. Journal of Donghua University:Natural Science Edition, 2015, 41(5): 625-630.
[6] 祝志峰. 纺织工程化学[M]. 上海:东华大学出版社, 2010:179-217.
ZHU Z F. Chemistry in Textile Engineering [M].Shanghai: Donghua University Press,2010:179-217.
[7] 王苗,祝志峰. 磺基丁二酸酯淀粉/PVA共混膜力学性能的研究[J]. 化工新型材料, 2014, 42(12):120-122.
WANG M, ZHU Z F. Inflence of blending ratio on the tensile property of sulfosuccinylated starch/polyvinyl alcohol blends[J]. New Chemical Materials, 2014, 42(12):120-122.
[8] ZHU Z F, CHENG Z Q. Effect of inorganic phosphates on the adhesion of mono-phosphorylated cornstarch to fibers[J]. Starch, 2008, 60(6):315-320.
[9] ZHU Z F, ZHU Z Q. Adhesion of starch-g-poly (2-acryloyloxyethyl trimethyl ammonium chloride) to cotton and polyester fibers[J]. Starch, 2014, 66(5-6): 566-575.
[10] SONG X Y, HE G Q, RUAN H, et al. Preparation and properties of octenyl succinic anhydride modified early indica rice starch[J]. Starch, 2006, 58(2):109-117.
[11] CHANG Y J, CHOI H W, KIM H S, et al. Physicochemical properties of granular and non-granular cationic starches prepared under ultra high pressure[J]. Carbohydrate Polymers, 2014, 99(5):385-393.
[12] CHI H, XU K, XUE D H, et al. Synthesis of dodecenyl succinic anhydride (DDSA) corn starch[J]. Food Research International, 2007, 40(10):232-238.
[13] ZHOU J, REN L L, TONG J, et al. Surface esteri?cation of corn starch ?lms: reaction with dodecenyl succinic anhydride[J]. Carbohydrate Polymers, 2009, 78(4):888-893.
[14] 祝志峰．淀粉与PVA类浆料混溶性的研究进展[J]．纺织高校基础科学学报，2003，16(4)：350-356．
ZHU Z F. Recent developments on the compatibility of starch -PVA sizes[J]. Basic Sciences Journal of Textile Universities, 2003，16(4)：350-356．

季铵醚化-辛烯基琥珀酸酯化淀粉与PVA共混膜力学性能研究

Study on Mechanical Properties of Quaternized and Octenylsuccinylated Starch/PVA Blend Films

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价